Home » Brands » Audi » Audi – Transmission Repair Service
Audi uses several very different automatic gearboxes. Most A3, A4, A5, A6, Q3 and Q5 models use S tronic dual-clutch (DSG) gearboxes, either the dry-clutch 7-speed in smaller A3 models or wet-clutch units in larger cars. The A8, Q7, Q8 and some older models use the ZF 8-speed tiptronic torque-converter automatic, and older A4 and A6 front-wheel-drive cars used the multitronic CVT. At Orange Auto in Al Quoz and Nad Al Hamar we identify your exact gearbox from the VIN, then diagnose and repair it with VAG diagnostic software, avoiding a costly full replacement wherever possible.
We confirm the gearbox code from your VIN, because a dry-clutch S tronic, a wet-clutch S tronic and a ZF tiptronic each fail and are repaired differently.
We read the transmission control unit and check clutch adaptation values, mechatronic pressures and temperatures.
We drive the car from cold to hot, in traffic and on the open road, to feel judder, slips and delayed shifts.
We check fluid level and condition and look for leaks at seals, cooler lines and the mechatronic unit.
Repairs range from a fluid and filter service to mechatronic unit repair, clutch pack replacement or a full gearbox rebuild. You approve the price first.
After any S tronic work we run the clutch and gear basic settings with diagnostic software, so the gearbox learns its new parts.
We road-test again and confirm smooth shifts and no stored faults before handover.
Ask us about the warranty on gearbox work when you get your quote.
The mechatronic unit is the hydraulic and electronic brain of an S tronic gearbox. Common faults include pressure accumulator failure on the dry-clutch 7-speed, solenoid and sensor faults, and internal leaks. Many units can be repaired rather than replaced, which saves a lot of money.
Wet-clutch S tronic gearboxes need a fluid and filter change, often around every 60,000 km. ZF tiptronic gearboxes are labelled lifetime-fill, but in Dubai heat we suggest a change around every 60,000 to 80,000 km. Clean fluid is the cheapest protection for an expensive gearbox. We check this during every Audi major service.
Bring your Audi to either Orange Auto workshop in Dubai. See all our Audi repair and service options.
Can an Audi S tronic gearbox be repaired?Yes. Most faults are in the mechatronic unit or the clutches, and both can be repaired without replacing the whole gearbox.
How long does an S tronic repair take?A fluid service is same day. Mechatronic or clutch work usually takes two to four days, depending on parts.
Is it safe to drive with a flashing gear display?Drive gently, only to the workshop. Continuing to drive can turn a small fault into major damage.
Book your Audi gearbox check at Orange Auto in Al Quoz or Nad Al Hamar. Call or WhatsApp us, or ask for a free quote using the form above.