Home » BMW Repair » BMW – Steering Repair
Older BMWs such as many E-series models use hydraulic power steering, while most models since the F-series use electric power steering (EPS) built into the steering rack. Some cars also have Active Steering or Integral Active Steering, which adds rear-wheel steering. Each system fails differently, so the repair must start with the right diagnosis. At Orange Auto in Al Quoz and Nad Al Hamar we repair BMW steering racks, EPS faults, power steering pumps and hoses, tie rods and steering angle sensor problems on all models.
We ask when the problem happens: at low speed, when parking, over bumps, or only when hot. Then we drive the car with you or on our own to feel and hear the fault.
We read the EPS, Active Steering and DSC modules with BMW ISTA. Fault codes and live data show motor current, steering angle and torque sensor values, which tell us whether the fault is electrical, mechanical or a calibration problem.
We check inner and outer tie rod ends, rack boots, the steering coupling and front suspension joints for play. On hydraulic systems we also check the fluid level, pump noise and hoses for leaks.
Uneven tyre wear, a pull or an off-centre wheel often comes from alignment rather than the rack. We check tyre wear and alignment before recommending any steering parts.
Depending on the fault we replace tie rods, rack boots, hoses or the pump, repair or replace the steering rack or EPS unit, and use genuine or OEM parts from brands such as ZF and Lemförder.
After steering work we run a four-wheel alignment, calibrate the steering angle sensor and initialise the EPS or Active Steering with ISTA, so driver assistance systems work correctly.
We road-test the car again, confirm the steering is straight and quiet, and explain what was done and anything else we noticed.
You approve every repair and price before we start, and we keep worn parts for you to see.
EPS faults are often caused by low battery voltage, a torque sensor fault or a failing motor or control unit in the rack. A weak battery alone can trigger a steering warning, so we test the battery first. When the rack itself has failed, we compare a repair with a replacement unit and give you both prices.
Speed bumps, potholes and parking with the wheels on full lock wear tie rods, rack bushes and rubber boots. Heat also hardens the rubber boots, and once a boot splits, sand and dust get into the rack. Checking the steering at every BMW major service catches this early.
Book your BMW steering check at our Al Quoz workshop or our BMW service centre in Nad Al Hamar. Related: BMW wheel alignment and BMW suspension repair.
Is it safe to drive with a BMW steering warning?The car can usually still be steered, but it may be very heavy. Drive slowly and only to the workshop.
Can a BMW steering rack be repaired?Often, yes. Leaking hydraulic racks and some EPS faults are repairable. We give you repair and replacement options.
Do I need an alignment after steering work?Yes. Any tie rod or rack work changes the alignment, so we always include it.
Book your BMW steering repair at Orange Auto in Al Quoz or Nad Al Hamar. Call or WhatsApp us, or ask for a free quote using the form above.